2005 Ford Crown Victoria Recall | On Certain Passenger Vehicles, The Battery Cable Includes A Fusible Link

2005 Ford Crown Victoria Electrical System,battery,cables Recall | Nov 09, 2005

On Certain Passenger Vehicles, The Battery Cable Includes A Fusible Link That May Contact And Subsequently Chafe On A #2 Cross Member Attaching Bolt.

This Condition May Result In Heat Damage And Could Lead To A Fire.

Summary Of Corrective Actions Taken: Dealers Will Inspect The Fusible Link And Position It Away From The Cross Member Bolt. If The Fusible Link Has Already Chafed And Copper Wires Have Been Exposed, The Fusible Link Will Be Replaced. The Recall Began On November 18, 2005. Owners May Contact Ford At 1-800-392-3673, Or Lincoln/mercury At 1-800-521-4140.

Ford Recall No. 05s38. Customers May Also Contact The National Highway Traffic Safety Administration’s Vehicle Safety Hotline At 1-888-327-4236 (tty 1-800-424-9153), Or Go To Http://www.safercar.gov.

This recall was issued on Nov 09, 2005 for 2005 Ford Crown Victoria, manufactured by FORD MOTOR COMPANY, in response to Electrical System,battery,cables problems.

2002 Ford Focus Recall | Certain Passenger Vehicles Equipped With Zetec Engines, Loose Or Broken Attachments

2002 Ford Focus Electrical System,battery,cables Recall | Nov 06, 2002

Certain Passenger Vehicles Equipped With Zetec Engines, Loose Or Broken Attachments And Misrouted Battery Cables Could Lead To Cable Insulation Damage.

This, In Turn, Could Cause The Battery Cables To Short Resulting In Heat Damage To The Cables. Besides Heat Damage, The “check Engine” Light May Illuminate, The Vehicle May Fail To Start, Or Smoke, Melting, Or Fire Could Also Occur.

Summary Of Corrective Actions Taken: Dealers Will Inspect The Battery Cables For The Condition Of The Cable Insulation And Proper Tightening Of The Terminal Ends. As Necessary, Cables Will Be Rerouted, Retaining Clips Installed, And Damaged Battery Cables Replaced. Owner Notification Began February 10, 2003. Owners Who Do Not Receive The Free Remedy Within A Reasonable Time Should Contact Ford At 1-866-436-7332.

Also Contact The National Highway Traffic Safety Administration’s Auto Safety Hotline At 1-888-dash-2-dot (1-888-327-4236).

This recall was issued on Nov 06, 2002 for 2002 Ford Focus, manufactured by FORD MOTOR COMPANY, in response to Electrical System,battery,cables problems.

2009 Ford F-650 Recall | Ldv Is Recalling 81 Trucks Built On Chevrolet And Ford My 2007-2009 C5500, My 2008-2009 W5500, And My 2008 F-650 Chassis Specifically For Snap-on Tools For Use As A Mobile Supply Company.

2009 Ford F-650 Electrical System,battery,cables Recall | Mar 19, 2009

Ldv Is Recalling 81 Trucks Built On Chevrolet And Ford My 2007-2009 C5500, My 2008-2009 W5500, And My 2008 F-650 Chassis Specifically For Snap-on Tools For Use As A Mobile Supply Company. There May Be A Cable Installed On The Battery Isolator With The Body Of The Cable Lug Facing The Isolator. With All Cables Tightened Down On The Stud, This Cable Lug May Be Pressed Against The Cooling Fins Of The Isolator, Where Contact Poses A Risk Of Electrical Short Which Could Result In Cables Overheating.this Contact Poses A Risk Of Electrical Short Which Could Result In Cables Overheating And A Fire Could Occur.. Follwoing Is The Summary Of Corrective Actions Taken: Dealers Will Conduct A Two-step Remedy. The First Step Is To Inspect The Cable Installation To Ensure All Cables Are Installed With The Lug Body Facing Away From The Isolator With None In Contact With The Cooling Fins. The Second Step Is To Add A Grounding Strap Or Able To He Aluminum Box To Properly Ground It And The Components Mounted Within It. The Recall Began On March 6, 2009. Owners May Contact Ldv At 608-257-3911.
owners May Also Contact The National Highway Traffic Safety Administration’s Vehicle Safety Hotline At 1-888-327-4236 (tty 1-800-424-9153), Or Go To http://www.safercar.gov .

This recall was issued on Mar 19, 2009 for 2009 Ford F-650, manufactured by LDV, INC., in response to Electrical System,battery,cables problems.

1990 Ford Thunderbird Recall | Battery To Starter Cables Are Longer Than Specified; Excessive Cable Length Could Contact Engine Damper Pulley.

1990 Ford Thunderbird Electrical System,battery,cables Recall | Feb 12, 1990

Battery To Starter Cables Are Longer Than Specified; Excessive Cable Length Could Contact Engine Damper Pulley.cable Protective Covering And Insulation Could Wear Through And Cause A Direct Short To Ground, Resulting In Overheating Of The Cable Insulation And Possibly A Underhood Fire.. Follwoing Is The Summary Of Corrective Actions Taken: Replace Battery To Starter Cable With Correct Length Cable.
system: Battery To Starter Cable.vehicle Description: Passenger Cars Equipped With 3.8 Liter Engines.

This recall was issued on Feb 12, 1990 for 1990 Ford Thunderbird, manufactured by FORD MOTOR COMPANY, in response to Electrical System,battery,cables problems.

1996 Ford F Super Duty Recall | A Plastic Coated Steel Support Strap For The Battery Cable Was Damaged When It Was Crimped Onto The Cable.

1996 Ford F Super Duty Electrical System,battery,cables Recall | Sept 18, 1996

A Plastic Coated Steel Support Strap For The Battery Cable Was Damaged When It Was Crimped Onto The Cable.this Damage Can Result In The Battery Cable Developing A Short To Ground. A Shorted Battery Cable Can Result In A Vehicle Fire.. Follwoing Is The Summary Of Corrective Actions Taken: Dealers Will Inspect The Cable Insulation And Replace The Support Strap With A Revised, Uncrimped Strap Attached With Tape. In Addition, Convolute Will Be Added Between The Cable And The Support Strap. Damaged Battery Cables Will Be Replaced.
owner Notification:owner Notification Is Expected To Being October 7, 1996. Note:owners Who Take Their Vehicles To An Authorized Dealer On An Agreed Upon Service Date And Do Not Receive The Free Remedy Within A Reasonable Time Should Contact Ford At 1-800-392-3673.also Contact The National Highway Traffic Safety Administration’s Auto Safety Hotline At 1-800-424-9393.

This recall was issued on Sept 18, 1996 for 1996 Ford F Super Duty, manufactured by FORD MOTOR COMPANY, in response to Electrical System,battery,cables problems.

1996 Ford Econoline Recall | The Battery Cable Harness Does Not Have Adequate Protection From Contacting And Being Damaged By The Right Engine Mount.

1996 Ford Econoline Electrical System,battery,cables Recall | Oct 02, 1996

The Battery Cable Harness Does Not Have Adequate Protection From Contacting And Being Damaged By The Right Engine Mount.if The Battery Cable Or Starter Wire Insulation Is Damaged By Such Contact, A Short To Ground Can Occur Resulting In Overheating Of The Wiring And Possible Ignition Of Surrounding Components.. Follwoing Is The Summary Of Corrective Actions Taken: Dealers Will Inspect For Chafing Of The Cable And Will Add Insulation And A Tie Strap To The Battery Cable Harness.
owner Notification:owner Notification Began October 14, 1996. Note:owners Who Take Their Vehicles To An Authorized Dealer On An Agreed Upon Service Date And Do Not Receive The Free Remedy Within A Reasonable Time Should Contact Ford At 1-800-392-3673.also Contact The National Highway Traffic Safety Administration’s Auto Safety Hotline At 1-800-424-9393.

This recall was issued on Oct 02, 1996 for 1996 Ford Econoline, manufactured by FORD MOTOR COMPANY, in response to Electrical System,battery,cables problems.

1998 Ford Ranger Ev Recall | Vehicle Description: Light Duty Electric Pickup Trucks Equipped With The Optional Traction Battery Heater System. This Battery Heater Could Have A Loose Crimp Connection Where The Power Wires Are Attached To

1998 Ford Ranger Ev Electrical System,battery,cables Recall | Apr 21, 1998

Vehicle Description: Light Duty Electric Pickup Trucks Equipped With The Optional Traction Battery Heater System. This Battery Heater Could Have A Loose Crimp Connection Where The Power Wires Are Attached To One Of The Heater Elements.the Loose Connection Could Arc Igniting Surrounding Materials.. Follwoing Is The Summary Of Corrective Actions Taken: Dealers Will Disable The Battery Pack Heaters.
owner Notification Began During April 1998.owners Who Are Not Contacted Directly By Ford Within A Reasonable Time Should Contact Ford At 1-800-392-3673.also Contact The National Highway Traffic Safety Administration’s Auto Safety Hotline At 1-888-dash-2-dot (1-888-327-4236).

This recall was issued on Apr 21, 1998 for 1998 Ford Ranger Ev, manufactured by FORD MOTOR COMPANY, in response to Electrical System,battery,cables problems.

1998 Ford F-350 Recall | Vehicle Description: Supercab Pickup Trucks. The Positive Battery Cable Is Taped To The Negative Cable Which Contains A Clip To Secure The Assembly To The Side Frame Rail. If

1998 Ford F-350 Electrical System,battery,cables Recall | Mar 12, 1998

Vehicle Description: Supercab Pickup Trucks. The Positive Battery Cable Is Taped To The Negative Cable Which Contains A Clip To Secure The Assembly To The Side Frame Rail. If Incorrectly Positioned, The Positive Battery Cable Can Contact The Air Conditioning Compressor Pulley.if The Cable Wears, A Complete Electrical System Failure Can Occur And Potential Sparking And/or Ignition Of Flammable Material.. Follwoing Is The Summary Of Corrective Actions Taken: Dealers Will Inspect And/or Modify The Battery Cable Clips To Ensure That They Are Properly Located.
owner/dealer Notification Began March 16,1998.owners Who Take Their Vehicles To An Authorized Dealer On An Agreed Upon Service Date And Do Not Receive The Free Remedy Within A Reasonable Time Free Of Charge Should Contact Ford At 1-800-248-0186. Also Contact The National Highway Traffic Safety Administration’s Auto Safety Hotline At 1-888-dash-2-dot (1-888-327-4236).

This recall was issued on Mar 12, 1998 for 1998 Ford F-350, manufactured by FORD MOTOR COMPANY, in response to Electrical System,battery,cables problems.

1998 Ford Supercab Recall | Vehicle Description: Supercab Pickup Trucks. The Positive Battery Cable Is Taped To The Negative Cable Which Contains A Clip To Secure The Assembly To The Side Frame Rail. If

1998 Ford Supercab Electrical System,battery,cables Recall | Mar 12, 1998

Vehicle Description: Supercab Pickup Trucks. The Positive Battery Cable Is Taped To The Negative Cable Which Contains A Clip To Secure The Assembly To The Side Frame Rail. If Incorrectly Positioned, The Positive Battery Cable Can Contact The Air Conditioning Compressor Pulley.if The Cable Wears, A Complete Electrical System Failure Can Occur And Potential Sparking And/or Ignition Of Flammable Material.. Follwoing Is The Summary Of Corrective Actions Taken: Dealers Will Inspect And/or Modify The Battery Cable Clips To Ensure That They Are Properly Located.
owner/dealer Notification Began March 16,1998.owners Who Take Their Vehicles To An Authorized Dealer On An Agreed Upon Service Date And Do Not Receive The Free Remedy Within A Reasonable Time Free Of Charge Should Contact Ford At 1-800-248-0186. Also Contact The National Highway Traffic Safety Administration’s Auto Safety Hotline At 1-888-dash-2-dot (1-888-327-4236).

This recall was issued on Mar 12, 1998 for 1998 Ford Supercab, manufactured by FORD MOTOR COMPANY, in response to Electrical System,battery,cables problems.