1981 Ford Exp Recall | Some Vehicles Equipped With Power Brake Boosters Have Front And Rear Shells That May Have Been Improperly Joined. Improperly Joined Booster Shells May Separate Either Partially Or Completely During Brake Application.

1981 Ford Exp Service Brakes, Hydraulic,power Assist,vacuum Recall | July 07, 1981

Some Vehicles Equipped With Power Brake Boosters Have Front And Rear Shells That May Have Been Improperly Joined. Improperly Joined Booster Shells May Separate Either Partially Or Completely During Brake Application.. Follwoing Is The Summary Of Corrective Actions Taken: All Defective Boosters Will Be Replaced At No Charge To Owner.
vehicle Description: Passenger Vehicles Equipped With Power Brake Boosters.system: Service Brakes; Power Brake Booster.consequences Of Defect: This Separation May Result In Total Loss Of The Servicebrakes Without Prior Warning, Loss Of Vehicle Control, And Possibly, Anaccident.note: Owner Is Advised To Contact Dealer Immediately To Find Out Whether Thedefect Was Corrected Prior To Vehicle Purchase. The Vehicle Should Not Bedriven Until The Problem Is Corrected.

This recall was issued on July 07, 1981 for 1981 Ford Exp, manufactured by FORD MOTOR COMPANY, in response to Service Brakes, Hydraulic,power Assist,vacuum problems.

1981 Ford Exp Recall | Certain Vehicles May Not Meet Applicable Minimum Fuel Spillage Requirements Of Federal Motor Vehicle Safety Standard No. 301, “fuel System Integrity”. During A 30 Mph Rear Impact Test, Fuel Spillage Limits

1981 Ford Exp Fuel System, Gasoline,storage,tank Assembly,filler Pipe And Cap Recall | Apr 07, 1981

Certain Vehicles May Not Meet Applicable Minimum Fuel Spillage Requirements Of Federal Motor Vehicle Safety Standard No. 301, “fuel System Integrity”. During A 30 Mph Rear Impact Test, Fuel Spillage Limits Were Exceeded By Vehicle.. Follwoing Is The Summary Of Corrective Actions Taken: Revised Fuel Filler And Vent Pipe Assemblies Will Be Installed On Affected Vehicles, Without Charge.
vehicle Description: Passenger Vehicles.system: Fuel; Fuel Filler And Vent Pipe Assembly.consequences Of Defect: Excessive Fuel Spillage Resulting From A Rear Impactcould Cause A Fire And Personal Injury If An Ignition Source Is Present.

This recall was issued on Apr 07, 1981 for 1981 Ford Exp, manufactured by FORD MOTOR COMPANY, in response to Fuel System, Gasoline,storage,tank Assembly,filler Pipe And Cap problems.

1983 Ford Exp Recall | Door Lock Pillars Could Develop Fatigue Cracks From Normal Usage Of Door, At The Point Where Door Latch Striker Reinforcements Are Attached.

1983 Ford Exp Latches/locks/linkages,doors,latch Recall | June 22, 1983

Door Lock Pillars Could Develop Fatigue Cracks From Normal Usage Of Door, At The Point Where Door Latch Striker Reinforcements Are Attached.. Follwoing Is The Summary Of Corrective Actions Taken: Any Damaged Lock Pillars Will Be Repaired And Reinforcements Will Be Installed Between The Door Latch Striker And Lock Pillars.
vehicle Description: Passenger Vehicles; Two Door.system: Structure; Door Lock Pillars.consequences Of Defect: Door May Not Latch Properly. In Driving Over Roughroads The Door Could Open, Allowing Passenger To Fall From Vehicle And Becomeinjured.

This recall was issued on June 22, 1983 for 1983 Ford Exp, manufactured by FORD MOTOR COMPANY, in response to Latches/locks/linkages,doors,latch problems.

1996 Ford Exp Recall | The Ignition Switch Could Experience An Internal Short Circuit.

1996 Ford Exp Electrical System,ignition Recall | Apr 25, 1996

The Ignition Switch Could Experience An Internal Short Circuit.this Condition Could Cause Overheating, Smoke, And Possibly Fire In The Steering Column Area Of The Vehicle.. Follwoing Is The Summary Of Corrective Actions Taken: Dealers Will Replace The Ignition Switch.
system: Electrical; Ignition Switch. Vehicle Description: Passenger And Multi-purpose Vehicles And Light Duty Trucks. Note: Owners Who Take Their Vehicles To An Authorized Dealer On An Agreed Upon Service Date And Do Not Receive The Free Remedy Within A Reasonable Time, Should Contact Ford At 1-800-392-3673. Also Contact The National Highway Traffic Safety Administration’s Auto Safety Hotline At 1-800-424-9393.

This recall was issued on Apr 25, 1996 for 1996 Ford Exp, manufactured by FORD MOTOR COMPANY, in response to Electrical System,ignition problems.

1982 Ford Exp Recall | On The Involved Vehicles, A Thermal Limiter In The Blower Motor Resistor Circuit Of The Air Conditioner/heater Assembly May Not Function As Intended. If The Blower Motor Becomes Jammed When The System Is

1982 Ford Exp Equipment,air Conditioner Recall | May 11, 1982

On The Involved Vehicles, A Thermal Limiter In The Blower Motor Resistor Circuit Of The Air Conditioner/heater Assembly May Not Function As Intended. If The Blower Motor Becomes Jammed When The System Is Operating In The Medium-low Blower Speed, The Resistor Coils Can Overheat Causing Melting And Possible Ignition.. Follwoing Is The Summary Of Corrective Actions Taken: Dealer Will Replace The Resistor Assembly With An Improved Version Without Charge To Owner.
vehicle Description: Passengers Vehicles Equipped With Optional Airconditioning.system: Air Conditioner; Motor, Fan.consequences Of Defect: A Vehicle Fire Could Result, Possibly Causing Loss Ofvehicle Control, Accident, And Passenger Injury.note: Until The Vehicle Is Serviced, The Blower Should Be Operated Only In Thehigh Or Low Speeds. The A/c Mode Lever Should Be Turned To The “off” Positionif The Blower Becomes Noisy Or If A Burning Odor Or Smoke Is Noticed.

This recall was issued on May 11, 1982 for 1982 Ford Exp, manufactured by FORD MOTOR COMPANY, in response to Equipment,air Conditioner problems.

1983 Ford Exp Recall | The Bolts That Attach The D-shaped Ring For The Shoulder Belt Are Inadequately Supported By The Material In Which They Are Mounted. The Attachment Does Not Comply With The Requirements Of Federal Motor Vehicle

1983 Ford Exp Seat Belts,front,anchorage Recall | Dec 20, 1983

The Bolts That Attach The D-shaped Ring For The Shoulder Belt Are Inadequately Supported By The Material In Which They Are Mounted. The Attachment Does Not Comply With The Requirements Of Federal Motor Vehicle Safety Standard No. 210, “seat Belt Assembly Anchorages”.. Follwoing Is The Summary Of Corrective Actions Taken: Dealers Will Install New Attaching Hardware To Improve The Strength Of The Mounting.
vehicle Description: Passenger Vehicles And Light Trucks.system: Interior Systems; Seat Belts And Upper Torso Restraint Attachments.consequences Of Defect: In Severe Collisions, The Shoulder Belt Attachmentcould Separate, Increasing The Possibility Of Occupant Injury.note: Manufacturer Advises That Seat Belts Should Continue To Be Used At Alltimes, As Substantial Benefits May Still Be Obtained.

This recall was issued on Dec 20, 1983 for 1983 Ford Exp, manufactured by FORD MOTOR COMPANY, in response to Seat Belts,front,anchorage problems.

1989 Ford Exp Recall | External Cracks Above The Number 3 Cylinder (1984 Models) Or Rocker Arm Cover Gaskets Splitting (1985 Models) Could Allow Oil To Leak Onto The Exhaust Manifold.

1989 Ford Exp Engine And Engine Cooling,engine Recall | June 12, 1989

External Cracks Above The Number 3 Cylinder (1984 Models) Or Rocker Arm Cover Gaskets Splitting (1985 Models) Could Allow Oil To Leak Onto The Exhaust Manifold.engine Oil Leaking Onto A Hot Exhaust Manifold Couldresult In An Engine Compartment Fire.. Follwoing Is The Summary Of Corrective Actions Taken: Replace Cracked Cylinder Heads (1984 Models); Replace Rocker Arm Cover Gaskets (1985 Models).
system:engine/cylinder Heads, Rocker Arm Cover Gaskets.vehicle Description:passenger Cars With 1.6l And 1.9l Engines.

This recall was issued on June 12, 1989 for 1989 Ford Exp, manufactured by FORD MOTOR COMPANY, in response to Engine And Engine Cooling,engine problems.